Monessen Hearth ILDV30PV Operations Instructions

0511ILDV cover9/0883D0511 8/11 Rev. 8

1083D0511ILDV20/30/40 Fireplace Insert• The damper and grate must be removed.• The smoke sh

83D0511ILDV20/30/40 Fireplace Insert11Consult local building codes before beginning the installation. The

183D0511ILDV20/30/40 Fireplace Insert• The exhaust vent must reline the entire length of chimney and termi

83D0511ILDV20/30/40 Fireplace Insert13This heater has been tested at altitudes ranging from sea level to 4

1483D0511ILDV20/30/40 Fireplace InsertFP1924inlet exhaust reline 9/08ExhaustInletRecommended block-off plat

83D0511ILDV20/30/40 Fireplace Insert15Before insert is placed back into replace opening, attach

1683D0511ILDV20/30/40 Fireplace InsertUse proper gas type for the insert you are installing. If you have conicting g

83D0511ILDV20/30/40 Fireplace Insert17A listed manual shutoff is factory installed upstream of appliance. Union tee and plugged 1/

1883D0511ILDV20/30/40 Fireplace Insert1. Check gas type. The gas supply must be the same as stated on the appliance’s rating decal.

83D0511ILDV20/30/40 Fireplace Insert19A remote wall switch and up to fteen (15) feet of 18 Ga. wire

83D0511ILDV20/30/40 Fireplace Insert

083D0511ILDV20/30/40 Fireplace Insert - This unit is supplied with six (6) ceramic ber logs. Do not handle these logs w

83D0511ILDV20/30/40 Fireplace Insert1LG538ILDV log #19/08Log #1LG538Figure 18 -Place Log #1LG539ILDV log #29/08Log #Figure 19 -Place L

83D0511ILDV20/30/40 Fireplace InsertLG540ILDV log #39/08Log #3LG540Figure 20 -Place Log #3LG541ILDV log #49/08Log #4Figure 21 -Place Lo

83D0511ILDV20/30/40 Fireplace Insert31. Remove glass door assembly. Page 29, Figure 34. Align cast or bevele

483D0511ILDV20/30/40 Fireplace Insert This appliance is equipped with a pilot which must be lit with built-in piezo ignitor

83D0511ILDV20/30/40 Fireplace Insert5PILOTOFFPILOTONContinued on next page You may check for gas leaks with the followin

683D0511ILDV20/30/40 Fireplace InsertPILOTOFFPILOTONFigure 30 - Off Position OFFPILOTONPILOTFP1937control knob onPILOTOFFPILOT

83D0511ILDV20/30/40 Fireplace Insert7The venturi of the burner is equipped with an air

883D0511ILDV20/30/40 Fireplace Insert1. Carefully remove upper l

83D0511ILDV20/30/40 Fireplace Insert9Turn off the unit and allow to cool completely. Turn off gas at shu

83D0511ILDV20/30/40 Fireplace Insert34. Never install the replace • in a recreational vehicle• where curtains, furniture, clothing, or other

3083D0511ILDV20/30/40 Fireplace InsertFP1945blowerWhite(Hi Temp)FP1946blower wiring diagramBlowerSnapDisc

83D0511ILDV20/30/40 Fireplace Insert31Make sure the gas valve knob is in the “OFF” position. Wait at least ve (5) minutes before start-ing maintenanc

383D0511ILDV20/30/40 Fireplace Insert1. Carefully remove log set, and embers from combustion chamber. . Va

83D0511ILDV20/30/40 Fireplace Insert33Failure to inspect and maintain heater may lead to improper combustion and a

3483D0511ILDV20/30/40 Fireplace Insert

83D0511ILDV20/30/40 Fireplace Insert3512/1324612345710111415171819202216232123252627280511ILDV parts9/0889

3683D0511ILDV20/30/40 Fireplace Insert         

83D0511ILDV20/30/40 Fireplace Insert37830511ILDV access231      1. Hood To

3883D0511ILDV20/30/40 Fireplace InsertThis product must be installed by a licensed plumber or gas tter when installed w

83D0511ILDV20/30/40 Fireplace Insert39The following components are warranted for life to the original

483D0511ILDV20/30/40 Fireplace InsertContinued from page 314. Do not use any solid fuels (wood, coal, pap

4083D0511ILDV20/30/40 Fireplace Insert149 Cleveland Drive • Paris, Kentucky 40361www.mhsc.com   

83D0511ILDV20/30/40 Fireplace Insert5• This appliance has been certied for use with either natural or propane gas. Refer to the app

683D0511ILDV20/30/40 Fireplace InsertIHGJKLCDFE0511ILDV dims9/08ABFigure 2 ILDV Fireplace Insert Dimensions    

83D0511ILDV20/30/40 Fireplace Insert7Read this homeowner manual thoroughly and follow all instructio

883D0511ILDV20/30/40 Fireplace InsertNo combustibles (ie: drapes, doors) may be within, or swing within 36" of the fro

83D0511ILDV20/30/40 Fireplace Insert9• The insert must be placed within a code-conforming masonry replace or a tested an