Monessen-hearth 624WBPF User Manual

MODEL 624WBPF PENINSULAINSTALLATION, OPERATION AND MAINTENANCE MANUALTHIS FIREPLACE IS LISTED BY OMNI-TEST LABORATORIES FOR USE WITH "L" SER

9FIREPLACE INSTALLATION53D9052. Rev 1 03/03LOCATION SELECTIONUnpack and check the fireplace and chimney for damage. If any items have been damaged, r

CHIMNEY INSTALLATION1053D9052. Rev 1 03/03

1153D9052. Rev 1 03/03CHIMNEY INSTALLATION

1253D9052. Rev 1 03/031. Lay out, cut and frame openings through all ceilings and the roof at the point where the chimney will pass through.Unless the

1353D9052. Rev 1 03/03CHIMNEY INSTALLATION

CHIMNEY INSTALLATION1453D9052. Rev 1 03/03

1553D9052. Rev 1 03/03CHIMNEY HEIGHT AND OFFSET CHARTS 17 26 1/2 31 3/4 36 41 1/4 47 1/4 50 3/4 57 3/4 62 67 3/4 72 1/2 77 1/2 82 88 92

1653D9052. Rev 1 03/03CHIMNEY CAP INSTALLATIONMODEL LC CHIMNEY CAPSPECIAL NOTE: The proper height as previously explained is important to assure prope

1753D9052. Rev 1 03/039. Install the chimney cap by placing the cap into matching parts of the last chimney section. Then punch ordrill 1/8 inch diam

1853D9052. Rev 1 03/03CHIMNEY CAP CHASE INSTALLATIONOUTSIDE COMBUSTION AIR RECOMMENDATIONS (CONTINUED)1. Extremely long runs and numerous turns in th

1You have chosen the finest wood burning fireplace available. Your fireplace has been designed foryears of heating and viewing enjoyment. Please tak

OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONSNOTE: The use of outside air for combustion is optional unless required by building codes. I

2053D9052. Rev 1 03/03GAS APPLIANCE INSTALLATIONWARNING: Improper installation or operation of a gas appliance in this fireplace can allow unburned g

2153D9052. Rev 1 03/03GAS APPLIANCE INSTALLATIONAPPLYING DECORATIVE TRIM TO THE FIREPLACEDo not allow the trim materials to extend closer than 3/8 inc

2253D9052. Rev 1 03/03All repair part orders should be placed through your local dealer. To ensure prompt and accurate service,please provide the foll

2353D9052. Rev 1 03/03FIREPLACE OPERATIONWARNING: If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an ope

2453D9052. Rev 1 03/03FIREPLACE OPERATIONA FEW WORDS OF CAUTIONBeware of burning certain material in your fireplace. Among these are plastics, poison

2553D9052. Rev 1 03/03MAINTENANCE AND SAFETYFUEL STORAGEWood can be dried sufficiently for burning within a few weeks if protected form rain in a low

2653D9052. Rev 1 03/03FIREPLACE MAINTENANCEAt the end of each heating season or when the fireplace will not be in use for an extended time, the ashess

2753D9052. Rev 1 03/0318. Do store your fuel supply at a distance equal to or greater than the spacing recommended for combustiblematerials from the f

2853D9052. Rev 1 03/03LIMITED WARRANTYFACTORY-BUILT FIREPLACE AND COMPONENTS(EXCEPT BLOWERS)WHAT IS COVERED AND FOR HOW LONG•FIVE-YEAR COVERAGE - For

1. Read these instructions entirely before beginning any part of the installation. Save these instructions forany future repairs.2. Use these instruc

2953D9052. Rev 1 03/03LIMITED WARRANTYYOUR DUTIESThis fireplace must be installed by a qualified installer according to your local building codes and

3053D9052. Rev 1 03/03NOTES

ATTENTIONAPPLIANCEINSTALLERPLEASE RETURN THESE OPERATINGAND INSTALLATION INSTRUCTIONS TO THE CONSUMER.53D9052. REV 1 03/03

53OPERATION GUIDELINESWhen a AK4 combustion air assembly and a combustion air duct are attached to the connecting point on theleft or right side of th

64CLEARANCES53D9052. Rev 1 03/03

FIREPLACE LOCATIONCAUTION: Do not install fireplace over carpeting.This fireplace does not require any special foundation. If the fireplace is to be

CLEARANCES653D9052. Rev 1 03/03

753D9052. Rev 1 03/03FIREPLACE COMPONENTSMODEL NUMBER DESCRIPTION624WBPF Peninsula Style FireplaceL48 4-foot chimney section (11-inch-diameter flue).L

853D9052. Rev 1 03/03FLOOR PROTECTIONIf this fireplace is installed on a combustible floor, the floor area 16 inches in front of, and 8 inches either