HWB600/HWB600HB MODELSINSTALLATION, OPERATION AND MAINTENANCE MANUALFOR RESIDENTIAL INSTALLATIONTHIS FIREPLACE IS U.L. LISTED FOR USE WITHTHE "L
MULTIPLE STORY INSTALLATIONMULTIPLE STORY INSTALLATIONATTIC SPACEATTIC SPACESINGLE STORY INSTALLATION WITHSINGLE STORY INSTALLATION WITH POOR PO
10FLOOR PROTECTIONIf this fireplace is installed on a combustible floor, the floor area 20 inches in front of, and 12 inches either sideof the firepla
52 7/8"52 7/8"27"27"53 1/8"53 1/8"68"68"20"20" FLOOR FLOORCOMBUSTIBLE COMBUSTIBLE 26 3/8&quo
12FIREPLACE COMPONENTS53D9035. Rev 1 03/03
13FIREPLACE INSTALLATIONLOCATION SELECTIONUnpack and check the fireplace and chimney for damage. If any items have been damaged, report this to yourd
CHIMNEY INSTALLATION141. Lay out, cut and frame openings through all ceilings and the roof at the point where the chimney will passthrough. Unless th
IMAGINARYCENTER POINT ACTUALCENTER POINTCENTERLINE OF CHIMNEYPLUMB BOBPLUMB LINETABLE 1TABLE 1MINIMUM REQUIRED ROOF OPENINGMINIMUM REQUIRED
CHIMNEY OFFSET INSTALLATION16ELBOW INSTALLATIONThe following are important points that should be observed when installing elbows on the fireplace:1. T
CHIMNEY OFFSET AND CAP INSTALLATION17CHIMNEY HOUSINGINSTALL ROUND CHIMNEY CAP ORCONTINUE CHIMNEY TO PROPER HEIGHT ANDSTORM COLSTORM COLLARFLASHFLASHIN
CHIMNEY CAP INSTALLATION18MODEL LC CHIMNEY CAPSPECIAL NOTE: The proper height as previously explained is important to assure proper draft and safety.
1You have chosen the finest wood burning fireplace available. Your fireplace has been designed foryears of heating and viewing enjoyment. Please tak
CHIMNEY HEIGHT AND OFFSET CHARTS19 17 17 26 1/2 26 1/2 31 3/4 31 3/4 36 36 41 1/4 41 1/4 47 1/4 47 1/4 50 3/4 50 3/4 57 3/4 57 3/4 62
CHIMNEY CAP CHASE INSTALLATION20The preinstalled chimney sections should be no more than 13 inches below the top of the chase. The installationshould
OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS21CONCRETE SLAB INSTALLATION (OPTIONAL OUTSIDE AIR RUNS)INLET GRILLE IN SOFFIT(OVERHANG)
OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS22OUTSIDE COMBUSTION AIR RECOMMENDATIONS (CONTINUED)1. Extremely long runs and numerous turns
COMBUSTION AIR ASSEMBLY23MODEL AK-4 COMBUSTION AIR ASSEMBLY1. Remove the cover plate from the 4-inch outlet opening location on the left outside of th
24GAS APPLIANCE INSTALLATIONWARNING: Improper installation or operation of a gas appliance in this fireplace can allow unburned gas to leakout which
GAS APPLIANCE INSTALLATION257. Pack the insulation removed in step 4 around the pipe to prevent air flowing through the tube either into orout of the
COMBUSTIBLESURROUNDPLACEMENTCOMBUSTIBLE SURROUND MATERIALS COMBUSTIBLE SURROUND MATERIALS MAY BE PLACED INSIDE THE SHADED MAY BE PLACED INSIDE
FIREPLACE OPERATIONWARNING: If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an openposition. (See addit
FIREPLACE OPERATIONA FEW WORDS OF CAUTIONBeware of burning certain material in your fireplace. Among these are plastics, poison ivy twigs and stems,a
1. Read these instructions entirely before beginning any part of the installation. Save these instructions forany future repairs.2. Use these instruc
29MAINTENANCE AND SAFETYFUEL STORAGEWood can be dried sufficiently for burning within a few weeks if protected form rain in a low humidity area. It i
FIREPLACE MAINTENANCEAt the end of each heating season or when the fireplace will not be in use for an extended time, the ashesshould be removed and t
18. Do store your fuel supply at a distance equal to or greater than the spacing recommended for combustiblematerials from the fireplace.19. Do build
32PARTS DIAGRAM AND LISTFIGURE 2653D9035. Rev 1 03/03All repair part orders should be placed through your local dealer. To ensure prompt and accurate
3353D9035. Rev 1 03/03PARTS DIAGRAM AND LISTFIGURE 27All repair part orders should be placed through your local dealer. To ensure prompt and accurate
3453D9035. Rev 1 03/03FACTORY-BUILT FIREPLACE AND COMPONENTS(EXCEPT BLOWERS)WHAT IS COVERED AND FOR HOW LONG•FIVE-YEAR COVERAGE - For five years from
LIMITED WARRANTYYOUR DUTIESThis fireplace must be installed by a qualified installer according to your local building codes and installation instructi
NOTES3653D9035. Rev 1 03/03
NOTES3753D9035. Rev 1 03/03
NOTES3853D9035. Rev 1 03/03
53OPERATION GUIDELINESWhen a AK4 combustion air assembly and a combustion air duct are attached to the connecting point on theleft of the fireplace, c
ATTENTIONAPPLIANCEINSTALLERPLEASE RETURN THESE OPERATINGAND INSTALLATION INSTRUCTIONS TO THE APPLIANCE FORCONSUMER USE.53D9035. REV 1 03/03
HWB700/HWB700HB MODELSINSTALLATION, OPERATION AND MAINTENANCE MANUALFOR RESIDENTIAL INSTALLATION53D9036. Rev 1 03/03THIS FIREPLACE IS U.L. LISTED FOR
1You have chosen the finest wood burning fireplace available. Your fireplace has been designed foryears of heating and viewing enjoyment. Please tak
1. Read these instructions entirely before beginning any part of the installation. Save these instructions forany future repairs.2. Use these instruc
53OPERATION GUIDELINESWhen a AK4 combustion air assembly and a combustion air duct are attached to the connecting point on theleft of the fireplace, c
64CLEARANCESRESIDENTIAL INSTALLATION53 3/8"53 3/8"MAINTAIN 2" MIN. AIR SPACEMAINTAIN 2" MIN. AIR SPACEBETWEEN CHIMNEY ANDBETWEE
CLEARANCES5NOTE: DIMENSIONS MAY VARY SLIGHTLY DUE TO MANUFACTURING TOLERENCES.NOTE: DIMENSIONS MAY VARY SLIGHTLY DUE TO MANUFACTURING TOLERENCES.4 5/1
FIREPLACE LOCATIONCAUTION: Do not install fireplace over carpeting.This fireplace does not weigh more than large pieces of furniture and can normall
8' 0"LEVEL SOLIDSURFACEFIRESTOP SPACER SEE NOTESJOIST INSULATE SAME AS CEILINGNOTES:1. MODEL LF-FS-2 FIRESTOP SPACER MUS
MULTIPLE STORY INSTALLATIONATTIC SPACESINGLE STORY INSTALLATION WITH POOR LOCATIONPREFERRED LOCATION2" MIN. CLEARANCE 2" MIN. CLEARANC
64CLEARANCES53D9035. Rev 1 03/03
9FLOOR PROTECTIONIf this fireplace is installed on a combustible floor, the floor area 20 inches in front of, and 12 inches either sideof the fireplac
52 7/8"52 7/8"27"27"53 1/8"53 1/8"68"68"20"20" FLOOR FLOORCOMBUSTIBLE COMBUSTIBLE 26 3/8&quo
1153D9036. Rev 1 03/03FIREPLACE COMPONENTSFIGURE 13
FIREPLACE INSTALLATIONLOCATION SELECTIONUnpack and check the fireplace and chimney for damage. If any items have been damaged, report this to yourdea
1353D9036. Rev 1 03/03CHIMNEY INSTALLATION1. Lay out, cut and frame openings through all ceilings and the roof at the point where the chimney will pas
IMAGINARY IMAGINARYCENTER POINT CENTER POINT ACTUAL ACTUALCENTER POINTCENTER POINTCENTERLINE CENTERLINE OF CHIMNEYOF CHIMNEYPLUMB BOBP
1553D9036. Rev 1 03/03CHIMNEY OFFSET INSTALLATIONELBOW INSTALLATIONThe following are important points that should be observed when installing elbows o
CHIMNEY OFFSET AND CAP INSTALLATIONCHIMNEY HOUSINGINSTALL ROUND CHIMNEY CAP ORCONTINUE CHIMNEY TO PROPER HEIGHT ANDSTORM COLSTORM COLLARFLASHFLASHINGR
1753D9036. Rev 1 03/03CHIMNEY CAP INSTALLATIONMODEL LC CHIMNEY CAPSPECIAL NOTE: The proper height as previously explained is important to assure prope
CHIMNEY HEIGHT AND OFFSET CHARTS 17 17 26 1/2 26 1/2 31 3/4 31 3/4 36 36 41 1/4 41 1/4 47 1/4 47 1/4 50 3/4 50 3/4 57 3/4 57 3/4 62 6
CLEARANCES553D9035. Rev 1 03/03
1953D9036. Rev 1 03/03CHIMNEY CAP CHASE INSTALLATIONThe preinstalled chimney sections should be no more than 13 inches below the top of the chase. Th
OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONSCONCRETE SLAB INSTALLATION (OPTIONAL OUTSIDE AIR RUNS)INLET GRILLE IN SOFFIT(OVERHANG)8&
2153D9036. Rev 1 03/03OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONSOUTSIDE COMBUSTION AIR RECOMMENDATIONS (CONTINUED)1. Extremely long run
COMBUSTION AIR ASSEMBLYMODEL AK-4 COMBUSTION AIR ASSEMBLY1. Remove the cover plate from the 4-inch outlet opening location on the left outside of the
2353D9036. Rev 1 03/03GAS APPLIANCE INSTALLATIONWARNING: Improper installation or operation of a gas appliance in this fireplace can allow unburned g
GAS APPLIANCE INSTALLATION7. Pack the insulation removed in step 4 around the pipe to prevent air flowing through the tube either into orout of the fi
2553D9036. Rev 1 03/03COMBUSTIBLESURROUNDPLACEMENTCOMBUSTIBLE SURROUND MATERIALS COMBUSTIBLE SURROUND MATERIALS MAY BE PLACED INSIDE THE SHADED
FIREPLACE OPERATIONWARNING: If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an openposition. (See addit
2753D9036. Rev 1 03/03FIREPLACE OPERATIONA FEW WORDS OF CAUTIONBeware of burning certain material in your fireplace. Among these are plastics, poison
MAINTENANCE AND SAFETYFUEL STORAGEWood can be dried sufficiently for burning within a few weeks if protected form rain in a low humidity area. It isf
6CLEARANCES53D9035. Rev 1 03/03
2953D9036. Rev 1 03/03FIREPLACE MAINTENANCEAt the end of each heating season or when the fireplace will not be in use for an extended time, the ashess
18. Do store your fuel supply at a distance equal to or greater than the spacing recommended for combustiblematerials from the fireplace.19. Do build
3153D9036. Rev 1 03/03PARTS DIAGRAM AND LISTFIGURE 26All repair part orders should be placed through your local dealer. To ensure prompt and accurate
3253D9036. Rev 1 03/03PARTS DIAGRAM AND LISTFIGURE 27All repair part orders should be placed through your local dealer. To ensure prompt and accurate
3353D9036. Rev 1 03/03FACTORY-BUILT FIREPLACE AND COMPONENTS(EXCEPT BLOWERS)WHAT IS COVERED AND FOR HOW LONG•FIVE-YEAR COVERAGE - For five years from
3453D9036. Rev 1 03/03LIMITED WARRANTYYOUR DUTIESThis fireplace must be installed by a qualified installer according to your local building codes and
ATTENTIONAPPLIANCEINSTALLERPLEASE RETURN THESE OPERATINGAND INSTALLATION INSTRUCTIONS TO THE APPLIANCE FORCONSUMER USE.53D9036. REV 1 03/03
FIREPLACE LOCATIONCAUTION: Do not install fireplace over carpeting.This fireplace does not weigh more than large pieces of furniture and can normall
8' 0"LEVEL SOLIDSURFACEFIRESTOP SPACER SEE NOTESJOIST INSULATE SAME AS CEILINGNOTES:1. MODEL LF-FS-2 FIRESTOP SPACER MUS
Comments to this Manuals