MODELS 624WBCL AND 624WBCRCORNER FIREPLACEINSTALLATION, OPERATION AND MAINTENANCE MANUALFOR RESIDENTIAL INSTALLATION53D9051. Rev 1 03/0336 INCH BUILT-
10All fireplaces installed over a combustible floor must incorporate a non-combustible hearth extension. It isrequired to protect the floor in front o
1153D9051. Rev 1 03/03CLEARANCES
1253D9051. Rev 1 03/03FIREPLACE INSTALLATION
1353D9051. Rev 1 03/03FIREPLACE INSTALLATION
14FIREPLACE INSTALLATIONLOCATION SELECTIONUnpack and check the fireplace and chimney for damage. If any items have been damaged, report this to yourd
15CHIMNEY INSTALLATION53D9051. Rev 1 03/033. Enclose the chimney where it passes through the living spaces to prevent contact with and possible damage
16CHIMNEY INSTALLATION53D9051. Rev 1 03/03
17CHIMNEY OFFSET INSTALLATIONELBOW INSTALLATIONNOTE: If triple wall elbow is to be placed directly to the top of the fireplace, it will be necessary t
18CHIMNEY OFFSET AND CAP INSTALLATION53D9051. Rev 1 03/03
1953D9051. Rev 1 03/03CHIMNEY OFFSET AND CAP INSTALLATION
2CONGRATULATIONS!You have chosen a fine woodburning fireplace. Your fireplace has been designed and built for yearsof heating and viewing enjoyment.
2053D9051. Rev 1 03/03CHIMNEY CAP INSTALLATIONMODEL SC CHIMNEY CAPSPECIAL NOTE: The proper height as previously explained is important to assure prope
2153D9051. Rev 1 03/03OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONSNOTE: The use of outside air for combustion is optional unless required
2253D9051. Rev 1 03/03COMBUSTION AIR ASSEMBLYMODEL OAC4 COMBUSTION AIR ASSEMBLY1. Remove the cover cap from the 4 inch outlet opening location on the
23GAS APPLIANCE INSTALLATION53D9051. Rev 1 03/03WARNING: Improper installation or operation of a gas appliance in this fireplace can allow unburned g
24GAS APPLIANCE INSTALLATIONThe face of your fireplace may be left exposed or trimmed with any noncombustible material such as brick,stone or marble.
25INSTALLATION OF NON-COMBUSTIBLE FACING MATERIALS TO THE FRONT FACE OF THEFIREPLACE FOR 624WBCL AND 624WBCRTRIM INSTALLATIONFIGURE 28NOTE: ON 624WBCL
2653D9051. Rev 1 03/03FIREPLACE OPERATIONWARNING: If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an ope
2753D9051. Rev 1 03/03WOOD VS. FOSSIL FUELSCompared to fossil fuels, a full cord of dry hickory weighs about two tons and is approximately equal in he
2853D9051. Rev 1 03/03FUEL STORAGEWood can be dried sufficiently for burning within a few weeks if protected form rain in a low humidity area. It isf
2953D9051. Rev 1 03/03FIREPLACE MAINTENANCEAt the end of each heating season or when the fireplace will not be in use for an extended time, the ashes
32IMPORTANT INFORMATION1. Read these instructions entirely before beginning any part of the installation. Save these instructions for anyfuture repai
3053D9051. Rev 1 03/0320. Do build fires of moderate intensity in the fireplace for the first three fires to allow materials to adjust andcure before
3153D9051. Rev 1 03/03PARTS DIAGRAM AND LISTAll repair part orders should be placed through your local dealer. To ensure prompt and accurate service,
53D9051. Rev 1 03/03ATTENTIONAPPLIANCE INSTALLER:PLEASE RETURN THIS INSTRUCTIONMANUAL TO THE CONSUMER.
45OPERATION GUIDELINESAs wood is burned in the fireplace, room air enters the air slot on the lower front edge and circulates around thefirebox.The ai
56CLEARANCES53D9051. Rev 1 03/03
6FIREPLACE COMPONENTS53D9051. Rev 1 03/03MODEL NUMBER DESCRIPTION624WBCL, 624WBCR Left or right end open fireplace. Includes wire firescreen, sealing
753D9051. Rev 1 03/03FIREPLACE INSTALLATION
8CHIMNEY COMPONENTS53D9051. Rev 1 03/031. When installing “E” series triple wall chimney system on the 624WBCL and B36LR, do not mix chimney systemcom
9SELECTING A LOCATION53D9051. Rev 1 03/03CAUTION: Do not install fireplace over carpeting.This fireplace does not require any special foundation. If
Comments to this Manuals